“Light This Candle”: The Hours Before Freedom 7

Carrying the hopes and dreams of a nation, Freedom 7 thunders into space. Less than a decade later, the career of the man inside – astronaut Alan Shepard – would culminate with a flight aboard a far more powerful rocket, the Saturn V, and include a landing on the Moon. Photo Credit: NASA

More than five decades ago, in the early hours of 5 May 1961, America prepared to launch its first man into space. Alan Shepard would fly a suborbital flight – rising from Cape Canaveral in the Mercury capsule he had named ‘Freedom 7’ and splashing down, just 15 minutes later, in the Atlantic Ocean, about 160 km north of the Bahamas – and it would be an understatement to say that the entire nation was holding its breath. Three weeks earlier, the Soviet Union had sent Yuri Gagarin on a fully orbital mission and although America was several months from repeating that achievement, the flight of Shepard would alleviate much pressure on the young administration of John Kennedy. Betwixt the launches of Gagarin and Shepard, the president’s ill-judged effort to overthrow Fidel Castro in Cuba had gone catastrophically wrong at the Bay of Pigs. The ‘peaceful’ achievement of the Soviets was being heavily compared to the ‘warmongering’ of the United States, but with Shepard a measure of success would finally be achieved…and a plot of the moral high ground secured.  

At 1:30 on the morning of the 5th, Shepard and his backup, fellow astronaut John Glenn, met at breakfast in the Cape Canaveral crew quarters, Hangar S. Both were clad in bathrobes. They subsequently parted to dress. Glenn headed out to Pad 5 to check Freedom 7, whilst Shepard underwent his pre-flight examination, performed by Air Force physician Bill Douglas. Four electrocardiograph pads were attached to his chest, a respirometer to his neck and a rectal thermometer to gauge deep body temperatures. Next came a set of long underwear, complete with spongy ‘pads’ to help air circulation. Finally, he squeezed into his silver space suit, securing zips and connectors and checking his briefcase-like air-conditioning unit. The latter was essential. By the time he was ready, Time magazine later reported, he was sweating profusely and breathing hard.

One unusual feature of the suit was that the fingers of its gloves were deliberately ‘curved’, to permit the grasping of controls, and its middle finger was ‘straight’ to enable Shepard to push buttons and flip toggles. To precisely tailor the suits, engineers had taken body moulds of the astronauts – dressing them in long underwear, covering them with brown paper tape and cutting the resultant mould – and Wally Schirra joked to Life magazine that it demanded “more alterations than a bridal gown”. When inflated, it only took one shape and any change to this shape – for example, by walking or trying to sit – forced the astronaut to exert himself to overcome the increased pressure.

Dressed in long underwear and fitted with biosensors, Alan Shepard dons the trousers of his silver pressure suit, early on 5 May 1961. Photo Credit: NASA

A few minutes before four in the morning, fellow astronaut Virgil ‘Gus’ Grissom accompanied Shepard in the transport van to a floodlit Pad 5, where technician Joe Schmitt fitted the gloves and Gordon Cooper briefed him on the countdown status. Meanwhile, at the top of the gantry, inside the cramped Freedom 7 capsule, John Glenn had spent almost two hours checking the readiness of each switch and instrument. At 5:15 am, Shepard ascended the elevator to reach a green-walled room at the 20 m level (nicknamed ‘The Greenhouse’), which surrounded the capsule’s hatch. After much huffing and puffing, the astronaut was inserted into his specially contoured couch. His first action was to chuckle aloud, for Glenn had put a girl pin-up and a placard, which read No Handball Playing in This Area. It was very unlike Glenn, who was normally considered a straight-arrow and not a prankster. He quickly pulled it down. Years later, Shepard’s biographer, Neal Thompson, would write that Glenn probably had second thoughts and did not want to risk having Freedom 7’s automatic cameras record his joke for dubious posterity.

Joe Schmitt, who suited and booted astronauts for more than two decades, remembered securing Shepard with straps across his shoulders, chest, lap, knees and even toes. Finally, Glenn reached in, shook his gloved hand and wished him luck. The hatch closed at 6:10 am and, by his own admission, Shepard’s heart rate quickened. Launch was scheduled for a little after 7:00 am, but this was soon delayed, as banks of clouds rolled over Florida’s south-eastern seaboard. Then, one of the power invertors to Freedom 7’s Redstone booster exhibited trouble. The countdown clock was recycled to T-35 minutes and, after an 86-minute wait, commenced counting again, once the invertor had been replaced. Next came an error with one of the computers at NASA’s Goddard Space Flight Center in Greenbelt, Maryland, which was responsible for processing the mission data. By the time this problem had been overcome, Shepard had been lying on his back for over three hours. Finally, a more ‘personal’ problem arose.

Not only was it uncomfortable to be lying inside the cramped capsule, but combined with the orange juice and coffee from breakfast it required him to urinate.

“Man, I gotta pee,” he finally radioed to Gordon Cooper, stationed in the nearby control blockhouse. “Check and see if I can get out quickly and relieve myself.”

No one had planned for this eventuality; with only a 15-minute flight scheduled, it had not been anticipated that Shepard would be inside Freedom 7 for long enough to feel ‘the urge’. Still, Cooper passed the request up the chain of command, to Wernher von Braun, the head of NASA’s Marshall Space Flight Center. The response was immediate and emphatic. In his thick German accent, von Braun retorted: “No! Ze astronaut shall stay in ze nosecone.” Exasperated – and in an exchange later removed from the official transcript – Shepard warned that he would urinate in his suit if he could not get outside. Managers wondered if the urine might short-circuit the medical wiring and electrical thermometers in his suit. Finally, Cooper confirmed that the power had been temporarily switched off and, shortly thereafter, a drawn-out “Ahhhhhh” emerged from the astronaut in the capsule. “I’m a wetback now,” Shepard added, as the warm fluid pooled in the small of his back.

More than 45 million Americans watched, listened and prayed as Alan Shepard headed into space. Photo Credit: NASA

In his post-flight debriefing, recorded an hour later aboard the USS Lake Champlain, Shepard acquiesced that his suit inlet temperature changed and may have affected one of his chest sensors, but his comfort was much improved. The urine was absorbed by his long cotton underwear and quickly evaporated in the 100-percent pure oxygen atmosphere of the cabin. Thankfully, the astronaut received no electric shocks and NASA, wrote Neal Thompson, was spared the humiliation of having to report that America’s first space traveller had been electrocuted by his own piss!

The clock was now marching rapidly towards 9:00 am. Two minutes remained on the countdown. Then, another halt was called. Pressures inside the Redstone’s liquid oxygen tank had climbed unacceptably high. NASA had two options. It could either reset the pressure valves – which would necessitate a launch scrub – or bleed off some of the pressure by remote control. An irritable Shepard, after almost four hours on his back and now lying in dried-up urine, obviously preferred the second option. “I’m cooler than you are!” he barked. “Why don’t you fix your little problem and light this candle?” Those final three words have since gained immortality and truly epitomise the ‘right stuff’ from which Shepard was cut. Finally, a little after 9:30 am, the clock resumed…and the television networks commenced their live coverage. By now, Cooper had been replaced by astronaut Deke Slayton, whose voice would crackle to and from Freedom 7 during the flight.

Thirty seconds to go. An umbilical cable, supplying electricity, communications and liquid oxygen, automatically separated from the Redstone, as planned.

Shepard’s pulse quickened from 80 to 126 beats per minute. His hand tightened on the capsule’s abort handle and in his mind he repeated, over and over, an early incarnation of ‘The Astronaut’s Prayer’: God help you if you screw up. He had been inside Freedom 7 for over four hours and the delays alone had cost three and a half hours – long enough to have flown his mission fourteen times over – but now it seemed that all was ready. The jolt of liftoff was not what he had expected. Rather than a harsh acceleration, he experienced something “extremely smooth…a subtle, gentle, gradual rise off the ground”.

At 9:34 am, with 45 million Americans watching or listening in person, on TV, on the radio or over loudspeakers, the Redstone roared aloft, prompting Shepard to activate the on-board timer and radio: “Roger…Liftoff…and the clock is started!” The nation could breathe an enormous, collective sigh of relief as their first astronaut speared for the heavens. Yet, as evidenced by a handful of disaster statements, prepared in advance by NASA’s public affairs officer, John ‘Shorty’ Powers, the mission could not be termed a success until Shepard was home, safe, and aboard the recovery ship, USS Lake Champlain. A tragedy, only the previous day, 4 May 1961, had already demonstrated how close the line came to triumph and tragedy in the exploration of the unknown. The 15 minutes and 28 seconds between launch and splashdown would prove heart-stopping.

 

The final part of this article will appear tomorrow.

One Comment

The powered up flight deck of space shuttle Endeavour. Photo Credit: Mike Killian / ARES Institute and Americaspace

PHOTO / VIDEO FEATURE: Shuttle Endeavour Readies For Final Power Down Of The STS Program

First Solar Eclipse For U.S. In Nearly Two Decades To Occur May 20